WATERLINK气提式丁板曝气器 WATERLINK Air-lifting T-plate Diffuser

气提式丁板式曝气器应用于好氧曝气池充氧的静止型曝气装置，它节能效果显著，根据我司经验相比表曝、射流等曝气器产品省电，但对比微孔曝气器电耗接近，但比微孔曝气器污泥量减少很多，约为20%以上（仅供参考）。

WATERLINK air-lifting T-plate diffuser is a static aeration device applied for oxygenating in aerobic aeration tanks, which brings a breakthrough change to sewage treatment aeration system. According to our company's experience, compared to traditional surface aerator, jet aerator and other aerator products, its energy-saving effect is significant. However, compared to microporous aerator, the electricity consumption is quite similar, but the sludge amount is reduced with around 20% or more (for reference only).

WATERLINK曝气器采用垂直安装方式，池内污水无需排放即可安装。

WATERLINK diffuser is installed vertically and without discharge.

设备结构及工作原理

气提式丁板曝气器采用气提原理，当气体进入曝气器后，使曝气器内部混合液密度低，在曝气器内部形成负压，从而将外部的泥水混合液吸入曝气器的底部，和通往的空气混合，避免了污泥在池底的堆积。泥水混合液从上部喷出，被气泡带到池子水面后自然下降，形成上下内循环。由于出泥水混合液在顶部倒伞式丁板的作用下使泥水汽均布分割，并起到分布均匀。所以每台曝气器的服务面积增大，同时达到泥水混合曝气的效果。

Structure and working principle

When the gas enters the diffuser, causing the low density of the mixed liquid and then forming negative pressure inside, so that the external sludge-water mixture is sucked into the bottom of the aerator, blending with the air to avoid the accumulation of sludge at the bottom of the tank. The sludge-water mixture is ejected from the top of diffuser and then falls naturally down to form an upper and lower inner cycle. The top umbrella T shape plate makes the uniform segmentation of the sludge-water-gas mixture, which results increasing of the aerator’s service area and reach effective aeration for the sludge-water mixture.

主要特点

1. 不排水可安装，可以快速维修
2. 工程造价低
3. 曝气汽从池底自然上升到水面，氧利用率高。
4. 空气阻力小，节能
5. 不带任何活动零部件，无损坏，免维修，使用尼龙、玻璃纤维制造，寿命长，不堵塞，性能稳定，供氧能力不会随时间的增加而衰减，保持池内稳定的DO值。
6. 底部有抽吸作用，内循环搅拌能力强，池底没有死泥堆积现象，曝气池氧化能力强。

Main features

1. Installed without drainage, able to quickly repaired
2. Low construction cost
3. Aerated gas rises from the bottom to the top to enhance the efficiency of the oxygen utilization
4. Low air resistance to save energy
5. Without any moving parts, no damage, no maintenance. Made of nylon and glass fiber offers long lifetime and no blockage. With stability performance, the supply capacity of oxygen will not weaken as time going and the Do concentration in tank keeps the same.
6.  Due to the suction at the bottom of the tank and strong internal circulation stirring, there is no sludge accumulation at the bottom and high oxidation capacity of aeration tank.

      技术参数  Parameters    (仅供参考)